Adsorptive Removal of Methyl Red from Aqueous Solution onto Charred and Aminated Sugarcane Waste

Authors

  • Jagjit Kour Central Department of Chemistry, Tribhuvan University, Kirtipur, Kathmandu, Nepal
  • Shankar Pandey Central Department of Chemistry, Tribhuvan University, Kirtipur, Kathmandu, Nepal
  • Puspa Lal Homagai Central Department of Chemistry, Tribhuvan University, Kirtipur, Kathmandu, Nepal
  • Megh Raj Pokhrel Central Department of Chemistry, Tribhuvan University, Kirtipur, Kathmandu, Nepal
  • Kedar Nath Ghimire Central Department of Chemistry, Tribhuvan University, Kirtipur, Kathmandu, Nepal

DOI:

https://doi.org/10.6000/1929-6037.2013.02.01.7

Keywords:

Methyl Red, Charred sugarcane waste, Aminated sugarcane waste, Adsorption-isotherm

Abstract

Adsorptive removal of Methyl Red (MR) from aqueous solution onto chemically modified charred sugarcane waste (CSW) and aminated sugarcane waste (ASW) has been investigated. The surface modification was characterized by FTIR, SEM, elemental analysis and Boehm titration. The effect of pH, contact time and MR concentrations were studied by batch equilibrium method. Maximum dye removal was observed at pH 2 onto CSW while that for ASW at pH 7. The dye can be quantitatively removed onto the surface of these adsorbents at a contact time of 3 h. Maximum adsorption capacity (qmax) for the CSW and ASW were found to be 125.0 mg/g and 142.85 mg/g, respectively. Adsorption kinetic data were tested using pseudo-first order, pseudo-second order and intra-particle diffusion models. Kinetic studies revealed that the adsorptive removal of the dye onto the adsorbents followed pseudo-second order kinetics model. The obtained results indicated an excellent alternative for the treatment of dye contaminated wastewater using such chemically modified sugarcane waste at low cost with better efficiency.

References

Rosemal M, Haris HM, Sathasivam K. The removal of methyl red from aqueous solutions using banana pseudo fibers. J Applied Sci 2009; 6: 1690-700. http://dx.doi.org/10.3844/ajassp.2009.1690.1700

Leechart P, Nakbanpote W, Thiravetyan P. Application of ‘waste’ wood-shaving bottom ash for adsorption of azo reactive dye. J Environ Manage 2009; 90: 912-20. http://dx.doi.org/10.1016/j.jenvman.2008.02.005

Forgacs E, Cserhatia T, Oros G. Removal of synthetic dyes from wastewaters. A review. Environ Int 2004; 30: 953-71. http://dx.doi.org/10.1016/j.envint.2004.02.001

McKay G, Porter JF, Prasad GR. The removal of dye colors from aqueous solutions by adsorption on low-cost materials. Water Air Soil Pollut 1998; 114: 423-38. http://dx.doi.org/10.1023/A:1005197308228

Amin KN. Removal of reactive dye from aqueous solutions by adsorption onto activated carbons prepared from sugarcane bagasse. Desalination 2008; 223: 152-61. http://dx.doi.org/10.1016/j.desal.2007.01.203

Chung KT, Fulk GE, Andrews AW. Mutagenicity testing of some commonly used dyes. Appl Environ Microbial 1981; 42: 641-48.

Jain R, Sikarwar S. Removal of hazardous dyes congored from waste material. J Hazard Mater 2008; 152: 942-48. http://dx.doi.org/10.1016/j.jhazmat.2007.07.070

So K, Wong P, Chang K. Decolorization and biodegration of methyl red by acetobacter liquefacien. Toxic Assess 1990; 5: 221-35. http://dx.doi.org/10.1002/tox.2540050303

Robinson T, McMullan G, Marchant R, Nigam P. Remediation of dyes in textile effluent: a critical review on current treatment technologies with a proposed alternative. Bioresour Technol 2001; 77: 247-55. http://dx.doi.org/10.1016/S0960-8524(00)00080-8

Aksu Z. Application of biosorption for the removal of organic pollutants: a review. Proc Biochem 2005; 40: 997-1026. http://dx.doi.org/10.1016/j.procbio.2004.04.008

Badar Y, El-Wahed MGA, Mahmoud MA. Photocatlytic degradation of methyl red by silica nanoparticles. J Hard Mater 2007; 154: 245-53. http://dx.doi.org/10.1016/j.jhazmat.2007.10.020

Kargi F, Sikarwar S. Biosorption performance of powered activated sludge for removal of different dyestuffs. Enz Microb Techno 2004; 35: 267-71. http://dx.doi.org/10.1016/j.enzmictec.2004.05.002

Han R, Zhang J, Zou W, Shi J, Liu H. Equilibrium biosorption isotherm for lead ion on chaff. J Hazard Mater 2005; 40: 997-1026.

Ho YS. Second-order Kinetic model for the sorption of cadmium onto tree fern: A comparison of linear and non-linear methods. Water Res 2006; 40: 119-25. http://dx.doi.org/10.1016/j.watres.2005.10.040

Santhi T, Manonmani S, Smitha T. Removal of methyl red from aqueous solution by activated carbon prepared from the Annona squmosa seed by adsorption. Chem Engin Res Bull 2010; 14: 11-18.

Han R, Wang Y, Zou W, Wang Y, Shi J. Comparison of linear and nonlinear analysis in estimating the Thomas model parameters for methylene blue adsorption onto natural zeolite in fixed-bed column. J Hazard Mater 2007; 145: 331-35. http://dx.doi.org/10.1016/j.jhazmat.2006.12.027

Poots VJP, McKay G, Healy JJ. Removal of basic dye from effluent using wood as an adsorbent. J Water Pollut Control Fed 1978; 50: 926-35.

Weber WJ, Morris JC. Advances in water pollution research: Removal of biologically-resistant pollutants from waste waters by adsorption. 2nd ed. London: In Proc. Intl. Conf. Water Pollution Symp Peragmon Oxford Press 1962; pp. 231-266.

Ofomaja AE. Kinetics and mechanism of methylene blue sorption onto palm kernal fiber. J Eng Biochem 2008; 40: 16-24.

Namasivayam C, Selvi K, Vanathi RA, Yamuna RT. ‘Waste’ coir pith-a potential biomass for the treatment of dyeing wastewaters. Biomass Bioenergy 2001; 31: 477-83. http://dx.doi.org/10.1016/S0961-9534(01)00052-6

Azahar S, Liew AG, Suhardy D, Hafiz D, Hatim MDI. Dye Removal from aqueous solution by using adsorption on treated sugarcane bagasse. Am J Applied Sci 2005; 2: 1499-503. http://dx.doi.org/10.3844/ajassp.2005.1499.1503

Annadurai G, Juang R, Lee D. Use of cellulose-based wastes for adsorption of dyes from aqueous solutions. J Haz Mat 2002; 92: 263-74. http://dx.doi.org/10.1016/S0304-3894(02)00017-1

Gong RM, Ding Y, Li M, Yang C, Liu HJ, Sun YZ. Utilization of powdered peanut hull as biosorbent for removal of anionic dyes from aqueous solution. Dyes Pigment 2005; 64: 187-94. http://dx.doi.org/10.1016/j.dyepig.2004.05.005

Xue SW, Yin Z, Yu J, Cheng S. The removal of basic dyes from aqueous solutions using agricultural by-products. J Haz Mat 2008; 157: 374-85. http://dx.doi.org/10.1016/j.jhazmat.2008.01.004

Lakshmi UR, Srivastava VC, Mall ID, Lataye DH. Rice husk ash as an effective adsorbent: Evaluation of adsorptive characteristics for Indigo Carmine dye. J Environ Manage 2009; 90: 710-20. http://dx.doi.org/10.1016/j.jenvman.2008.01.002

Uddin MT, Islam MA, Mahmud S, Rukanuzzaman M. Adsorptive removal of methylene blue by tea waste. J Haz Mat 2009; 164: 53-60. http://dx.doi.org/10.1016/j.jhazmat.2008.07.131

Onal Y, Akmil-Basar C, Sarici-Ozdemir C. Elucidation of the naproxen sodium adsorption onto activated carbon prepared from waste apricot: Kinetic, equilibrium and thermodynamic characterization. J Haz Mat 2007; 148: 727-34. http://dx.doi.org/10.1016/j.jhazmat.2007.03.037

Hameed BH, Daud FBM. Adsorption studies of basic dye on activated carbon derived from agricultural waste: Hevea brasiliensis seed coat. J Eng Chem 2008; 139: 48-55. http://dx.doi.org/10.1016/j.cej.2007.07.089

Singh KP, Malik A, Sinha S, Ojha P. Liquid-phase adsorption of phenols using activated carbons derived from agricultural waste material. J Haz Mat 2008; 150: 626-41. http://dx.doi.org/10.1016/j.jhazmat.2007.05.017

Robinson T, Chandran B, Nigam P. Removal of dyes from a synthetic textile dye effluent by biosorption on apple pomace and wheat straw. Water Res 2002; 36: 2824-30. http://dx.doi.org/10.1016/S0043-1354(01)00521-8

Dogan M, Abak H, Alkan M. Adsorption of methylene blue onto hazelnut shell: Kinetics, mechanism and activation parameters. J Haz Mat 2009; 164: 172-81. http://dx.doi.org/10.1016/j.jhazmat.2008.07.155

Tseng RL. Physical and chemical properties and adsorption type of activated carbon prepared from plum kernels by NaOH activation. J Haz Mat 2007; 147: 1020-27.

Robinson T, Chandran B, Nigam P. Removal of dyes from an artificial textile dye effluent by two agricultural waste residues, corncob and barley husk. Environ Int 2002; 28: 29-33. http://dx.doi.org/10.1016/S0160-4120(01)00131-3

Homagai PL, Ghimire KN, Inoue K. Preparation and Characterization of Charred Xanthated Sugarcane Bagasse for the Separation of Heavy Metals from Aqueous Solutions. Separation Sci Tech 2011; 46: 330-39. http://dx.doi.org/10.1080/01496395.2010.506903

Hameed BH, Din ATM, Ahmad AL. Adsorption of methylene blue onto bamboo-based activated carbon: Kinetics and equilibrium studies. J Haz Mat 2007; 141: 819-25. http://dx.doi.org/10.1016/j.jhazmat.2006.07.049

Hameed BH. Grass waste: A novel sorbent for the removal of basic dye from aqueous solution. J Haz Mat 2009; 166: 233-38. http://dx.doi.org/10.1016/j.jhazmat.2008.11.019

Hameed BH, El-Khaiary MI. Removal of basic dye from aqueous medium using a novel agricultural waste material: Pumpkin seed hull. J Haz Mat 2008; 155: 601-609. http://dx.doi.org/10.1016/j.jhazmat.2007.11.102

Hameed BH, Ahmad AA. Batch adsorption of methylene blue from aqueous solution by garlic peel, an agricultural waste biomass. J Haz Mat 2009; 164: 870-75. http://dx.doi.org/10.1016/j.jhazmat.2008.08.084

Ghimire KN, Inoue K, Miyajima T, Yoshizuka K, Shoji T. Adsorption of some metal ions and minerals acids on chitin. Chitin Chitosan Res 2001; 7: 61-68.

Silverstein RM, Bassler GC, Morril TC. Spectrometric identification of Organic Compounds. 4th ed. John Willy and Sons: New York 1981; pp.127-30.

Osvaldo KJ, Gurel LVA, De Melo JCP, Botaro VR, Melo TMS, Gil RPF, et al. Adsorption of heavy metal ion from aqueous single metal solution by chemically modified sugarcane bagasse. Bioresour Tech 2007; 98: 1291-97. http://dx.doi.org/10.1016/j.biortech.2006.05.013

Xiao B, Sun XF, Sun R. The chemical modification of lignins with succinic anhydride in aqueous systems. Polym Degrad Stability 2001; 71: 223-31. http://dx.doi.org/10.1016/S0141-3910(00)00133-6

Navarro RR, Sumi K, Fujii N, Matsumura M. Mercury removal from wastewater using porous cellulose carrier modified with polyethyleneimine. Water Res 1996; 30: 248-49. http://dx.doi.org/10.1016/0043-1354(96)00143-1

Downloads

Published

2013-02-27

How to Cite

Kour, J., Pandey, S., Homagai, P. L., Pokhrel, M. R., & Ghimire, K. N. (2013). Adsorptive Removal of Methyl Red from Aqueous Solution onto Charred and Aminated Sugarcane Waste. Journal of Membrane and Separation Technology, 2(1), 63–73. https://doi.org/10.6000/1929-6037.2013.02.01.7

Issue

Section

Articles