Combination of Adsorption-Diffusion Model with Computational Fluid Dynamics for Simulation of a Tubular Membrane Made from SAPO-34 Thin Layer Supported by Stainless Steel for Separation of CO2 from CH4

Authors

  • Fatemeh Sadat Banitaba School of Chemical Engineering, College of Engineering, University of Tehran, Iran
  • Zahra Mansourpour School of Chemical Engineering, College of Engineering, University of Tehran, Iran
  • Shohreh Fatemi School of Chemical Engineering, College of Engineering, University of Tehran, Iran

DOI:

https://doi.org/10.6000/1929-6037.2016.05.01.2

Keywords:

Computational fluid dynamic, tubular zeolite membrane, CO2/CH4 separation, SAPO-34, Adsorption-diffusion mechanism

Abstract

Modeling of CO2/CH4 separation using SAPO-34 tubular membrane was performed by computational fluid dynamics. The Maxwell-Stefan equations and Langmuir isotherms were used to describe the permeate flux through the membrane and the adsorption-diffusion, respectively. Three-dimensional Navier-Stokes momentum balances in feed and permeate side coupled with adsorption-diffusion equations from the membrane were simultaneously solved by ANSYS FLUENT software. The velocity and concentration profiles were determined in both feed and permeate sides. There was a good agreement between simulation and experimental results and root mean square deviation for CH4 and CO2 are 0.13 and 0.1 (mmol m-2 s-1), respectively. The concentration polarization effect was observed in the results. The effect of the process variables were investigated to find out the most influential parameters in permeation and purity. The impact of operating conditions on separation were studied and showed that for enhancement of separation efficiency of CO2 from CH4, feed pressure, feed flow rate and tube radius and number of membrane modules in series should be increased, whereas flow configuration has less significant effect.

References

Baker RW. Future Directions of Membrane Gas Separation Technology. Ind Eng Chem Res 2002; 41(6): 1393-411. http://dx.doi.org/10.1021/ie0108088

Rufford TE, Smart S, Watson GCY, Graham BF, Boxall J, Diniz da Costa JC, et al. The removal of CO2 and N2 from natural gas: A review of conventional and emerging process technologies. J Pet Sci Eng 2012; 94-95: 123-54. http://dx.doi.org/10.1016/j.petrol.2012.06.016

Sridhar S, Smitha B, Aminabhavi TM. Separation of carbon dioxide from natural gas mixtures through polymeric membranes—A Review. Sep Purif Rev 2007; 36(2): 113-74. http://dx.doi.org/10.1080/15422110601165967

Hong M, Li S, Falconer JL, Noble RD. Hydrogen purification using a SAPO-34 membrane. J Memb Sci 2008; 307(2): 277-83. http://dx.doi.org/10.1016/j.memsci.2007.09.031

Krishna R, van Baten JM. Segregation effects in adsorption of CO2-containing mixtures and their consequences for separation selectivities in cage-type zeolites. Sep Purif Technol 2008; 61(3): 414-23. http://dx.doi.org/10.1016/j.seppur.2007.12.003

Ghidossi R, Veyret D, Moulin P. Computational fluid dynamics applied to membranes: State of the art and opportunities. Chem Eng Process 2006; 45(6): 437-54. http://dx.doi.org/10.1016/j.cep.2005.11.002

Fimbres-Weihs GA, Wiley DE. Review of 3D CFD modeling of flow and mass transfer in narrow spacer-filled channels in membrane modules. Chem Eng Process 2010; 49(7): 759-81. http://dx.doi.org/10.1016/j.cep.2010.01.007

Koukou MK, Papayannakos N, Markatos NC, Bracht M, Van Veen HM, Roskam A. Performance of ceramic membranes at elevated pressure and temperature: effect of non-ideal flow conditions in a pilot scale membrane separator. J Memb Sci. 1999; 155(2): 241-59. http://dx.doi.org/10.1016/S0376-7388(98)00315-9

Takaba H, Nakao Si. Computational fluid dynamics study on concentration polarization in H2/CO separation membranes. J Memb Sci 2005; 249(1-2): 83-8. http://dx.doi.org/10.1016/j.memsci.2004.09.038

Abdel-jawad MM, Gopalakrishnan S, Duke MC, Macrossan MN, Schneider PS, Diniz da Costa JC. Flowfields on feed and permeate sides of tubular molecular sieving silica (MSS) membranes. J Memb Sci 2007; 299(1-2): 229-35. http://dx.doi.org/10.1016/j.memsci.2007.04.046

Kawachale N, Kumar A, Kirpalani DM. Numerical Investigation of Hydrocarbon Enrichment of Process Gas Mixtures by Permeation through Polymeric Membranes. Chem Eng Technol 2008; 31(1): 58-65. http://dx.doi.org/10.1002/ceat.200700263

Coroneo M, Montante G, Catalano J, Paglianti A. Modelling the effect of operating conditions on hydrodynamics and mass transfer in a Pd-Ag membrane module for H2 purification. J Memb Sci 2009; 343(1-2): 34-41. http://dx.doi.org/10.1016/j.memsci.2009.07.008

Coroneo M, Montante G, Giacinti Baschetti M, Paglianti A. CFD modelling of inorganic membrane modules for gas mixture separation. Chem Eng Sci 2009; 64(5): 1085-94. http://dx.doi.org/10.1016/j.ces.2008.10.065

Ji G, Wang G, Hooman K, Bhatia S, Diniz da Costa JC. Simulation of binary gas separation through multi-tube molecular sieving membranes at high temperatures. Chem Eng J 2013; 218: 394-404. http://dx.doi.org/10.1016/j.cej.2012.12.063

Ji G, Wang G, Hooman K, Bhatia S, Diniz da Costa JC. The fluid dynamic effect on the driving force for a cobalt oxide silica membrane module at high temperatures. Chem Eng Sci 2014; 111: 142-52. http://dx.doi.org/10.1016/j.ces.2014.02.006

Li H, Schygulla U, Hoffmann J, Niehoff P, Haas-Santo K, Dittmeyer R. Experimental and modeling study of gas transport through composite ceramic membranes. Chem Eng Sci 2014; 108: 94-102. http://dx.doi.org/10.1016/j.ces.2013.12.030

Jabbari Z, Fatemi S, Davoodpour M. Improvement of SAPO-34 fine layer formation on ceramic and steel supports by applying uniform-size synthesized seed particles. Asia-Pac J Chem Eng 2013; 8(2): 301-10. http://dx.doi.org/10.1002/apj.1682

Jareman F, Hedlund J, Creaser D, Sterte J. Modelling of single gas permeation in real MFI membranes. J Memb Sci 2004; 236(1-2): 81-9. http://dx.doi.org/10.1016/j.memsci.2004.01.028

Nagy E. Basic Equations of the Mass Transport through a Membrane Layer. First ed. Oxford: Elsevier; 2012. 330 p.

Wirawan SK, Creaser D, Lindmark J, Hedlund J, Bendiyasa IM, Sediawan WB. H2/CO2 permeation through a silicalite-1 composite membrane. J Memb Sci 2011; 375(1-2): 313-22. http://dx.doi.org/10.1016/j.memsci.2011.03.061

Martinek JG, Gardner TQ, Noble RD, Falconer JL. Modeling Transient Permeation of Binary Mixtures through Zeolite Membranes. Ind Eng Chem Res 2006; 45(17): 6032-43. http://dx.doi.org/10.1021/ie060166u

Ansys Fluent User's Guide, Release 13.0: Ansys Inc.; 2010.

Li S, Falconer JL, Noble RD, Krishna R. Modeling Permeation of CO2/CH4, CO2/N2, and N2/CH4 Mixtures Across SAPO-34 Membrane with the Maxwell−Stefan Equations. Ind Eng Chem Res 2007; 46(12): 3904-11. http://dx.doi.org/10.1021/ie0610703

Downloads

Published

2016-04-06

How to Cite

Sadat Banitaba, F., Mansourpour, Z., & Fatemi, S. (2016). Combination of Adsorption-Diffusion Model with Computational Fluid Dynamics for Simulation of a Tubular Membrane Made from SAPO-34 Thin Layer Supported by Stainless Steel for Separation of CO2 from CH4. Journal of Membrane and Separation Technology, 5(1), 16–24. https://doi.org/10.6000/1929-6037.2016.05.01.2

Issue

Section

Special Issue : Membranes for Carbon Dioxide Separation / Capture Applications